 |
H2O2 Hydrogen Peroxide SDS Safety Data Sheet of Supplier Exporter Manufacturers' Representative |
Email: info@ammol.org |
Call Toll Free +1-855-552-6665 |
Hydrogen Peroxide
CAS Number: 7722-84-1
Molecular Formula: H2O2
Molecular Weight: 34.01
Hydrogen Peroxide
Hydrogen Peroxide SDS, Safety Data Sheet
MSDS Sheet, Material Safety Data Sheet 04-Feb-24
Section 1. Product Information
Product Name & Other Names: Hydrogen Peroxide.
CAS No.: 7722-84-1
EINECS EC Number: 231-765-0
Relevant uses and uses advised against (if any): Industrial Manufacturing.
Supplier: American Molecules, 9910 Bent Oak Dr, Houston, TX 77040, USA.
Call Toll Free: 1-855-55-AMMOL 1-855-552-6665.
In case of emergency contact: Will be given with the supply.
Section 2: Hazards Identification
GHS, Globally Harmonized System Classification in accordance with 29 CFR 1910
Classification according to Regulation (EC) No 1272/2008
Oxidizing liquids; oxidizing solids Category 3, H272
Acute toxicity, oral Category 3, H301
Skin corrosion/irritation Category 1A, B, C H314
Acute toxicity (inhalation) Category 4, H332
Specific target organ toxicity - single exposure, Category 3, H335
Chronic aquatic toxicity (Category 3), H412
Labeling according to GHS & Regulation (EC) No 1272/2008
GHS Label Elements  Aquatic Toxicity |
GHS Label Elements |
GHS Label Elements |
GHS Label Elements |
Signal Words: Danger
Hazard statements:
H272 May intensify fire; oxidizer
H301 Toxic if swallowed.
H314 Causes severe skin burns and eye damage.
H332 Harmful if inhaled
H335 May cause respiratory irritation.
H412 Harmful to aquatic life with long lasting effects.
Precautionary statements:
P202: Do not handle until all safety precautions have been read and understood.
P210: Keep away from heat/sparks/open flames/hot surfaces – No smoking.
P220: Keep/Store away from clothing/…/combustible materials.
P260: Do not breathe dust/fume/gas/mist/vapors/spray.
P270: Do not eat, drink or smoke when using this product.
P280: Wear protective gloves/protective clothing/eye protection/face protection.
P301+310: IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician.
P303+361+353: IF ON SKIN (or hair): Remove/Take off immediately all contaminated clothing. Rinse skin with water/shower.
P304+340: IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing.
P332+313: If skin irritation occurs: Get medical advice/attention.
P305+351+338: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do – continue rinsing.
Other Information: Keep container in a cool place out of direct sunlight. Store only in vented containers. Avoid storing on wooden pallets. Avoid contamination - Contamination could cause decomposition and generation of oxygen which may result in possible container rupture.
Section 3: Composition and Information on Ingredients
Product Name & Other Names: Hydrogen Peroxide.
CAS No.: 7722-84-1
EINECS EC Number: 231-765-0
Percentage: >30% and <70% in water.
Section 4. First Aid & Procedure
Always get medical attention after the first aid is over.
Ingestion: Never give anything by mouth to an unconscious person. Get medical attention.
Skin: Immediately flush skin with plenty of water for at least 15 minutes. Remove and wash contaminated clothing and shoes before reuse. Get medical attention if irritation develops.
Eyes: Immediately flush eyes with plenty of water for 15 minutes, occasionally lifting upper and lower eyelids. Hold eyelids apart during irrigation. Get medical attention.
Inhalation: Remove person to fresh air. If breathing is difficult, give oxygen. If not breathing administer artificial respiration. Get medical attention.
Hydrogen peroxide is a strong oxidant. Direct contact with the eye is likely to cause corneal damage especially if not washed immediately. Careful opthalmologic evaluation is recommended and the possibility of local corticosteroid therapy should be considered. Because of the likelihood of corrosive effects on the gastrointestinal tract after ingestion, and the unlikelihood of systemic effects, attempts at evacuating the stomach via emesis induction or gastric lavage should be avoided.
Section 5. Fire Fighting Measures
Flash Point: N/A
Fire/Explosion: The product is not combustible, but it is an oxidizer.
Extinguishing Medium: Water. Do not use any other substance.
Hazardous Combustion Products: On decomposition product releases oxygen which may intensify fire.
Fire Fighting Instructions: Use suitable protective equipment for surrounding fire.
In closed unventilated containers, risk of rupture due to the increased pressure from decomposition. Contact with combustible material may cause fire.
Special Information: In the event of a fire, wear full protective clothing and NIOSH-approved self-contained breathing apparatus with full face piece operated in the pressure demand or other positive pressure mode.
Section 6. Spills and Disposals
Personal precautions, protective equipment and emergency procedures: Avoid breathing dust/fumes/gas/mist/vapors/spray. Use individual protective equipment (waterproof boots, suitable protective clothing, safety glasses, etc.). Restrict unprotected personnel from the area. Prevent any contact with hot surfaces. Do not approach facing the wind.
Environmental precautions: Do not let the product enter drains, soil or water sources.
Methods and materials used for containment Cleanup procedures and Storage:
Dike to collect large liquid spills. Stop leak and contain spill if this can be done safely. Pick up and arrange disposal without creating mist/dust. Sweep up and shovel. Keep in suitable, closed containers for disposal. Avoid mist formation. Avoid breathing vapors, dust/mist or gas. Ensure adequate ventilation. Don't touch or walk through this product. Stop leak if safe to do so. Prevent entry into waterways, drains, confined areas. Collect material and place it into loosely covered plastic containers for later disposal.
Combustible materials exposed to hydrogen peroxide should be immediately submerged in or rinsed with large amounts of water to ensure that all hydrogen peroxide is removed. Residual hydrogen peroxide that is allowed to dry (upon evaporation hydrogen peroxide can concentrate) on organic materials such as paper, fabrics, cotton, leather, wood or other combustibles can cause the material to ignite and result in fire.
Section 7. Handling and Storage
Toxic Hazardous material.
Precautions for safe handling: Avoid prolonged or repeated exposure. Apply according to good manufacturing and industrial hygiene practices. Ensure proper ventilation. Wash thoroughly after handling. Do not drink, eat or smoke while handling. Avoid contact with skin, eyes and clothing. Minimize dust generation. Avoid breathing dust/fumes/gas/mist/vapors/spray. Keep container tightly closed. Avoid ingestion and inhalation. Use individual protective equipment (waterproof boots, suitable protective clothing, safety glasses, etc.).
Conditions for safe storage, including any incompatibilities: Store in cool, dry and ventilated area away from heat sources and protected from sunlight in tightly closed original container. Keep air contact to a minimum. Do not leave the material container open. Store protected from heat, sparks and ignition sources and incompatible materials. Keep/Store away from clothing/ combustible materials. Isolate from all combustibles and incompatible substances. Avoid contact with skin and eyes. Avoid inhalation of dust/mist/vapor. Do not store with incompatible materials like organic materials, powdered metals, strong reducing agents. Hydrogen peroxide should be stored only in vented containers and transferred only in a prescribed manner.
Section 8. Exposure Controls & Personal Protection
Exposure Limits: ACGIH TLV: TWA: 1 ppm, OSHA PEL: TWA: 1 ppm & TWA: 1.4 mg/m3
Engineering Controls: Use adequate exhaust ventilation to keep airborne concentrations low.
Ventilation System: A system of local and/or general exhaust is recommended to keep employee exposures as low as possible.
Personal Respirators (NIOSH Approved): For conditions of use where exposure to dust or mist is apparent and engineering controls are not feasible, a particulate respirator may be worn.
Skin Protection: Wear protective gloves and clean body-covering clothing.
Eye Protection: Use chemical safety goggles and/or full face shield where dusting or splashing of solutions is possible. Maintain eye wash fountain and quick-drench facilities in work area.
Other Control Measures: Maintain good housekeeping in work area. Handle in accordance with good industrial hygiene and safety practice. Wash hands after handling.
Section 9. Physical & Chemical Data
Appearance: Clear Colorless Liquid.
Odor: None
Odor threshold: Not applicable.
pH: Varies with assay
Specific Gravity: Varies with assay
Melting Point: Varies with assay
Initial boiling point and boiling range: No data found.
Flash point: No data found.
Auto-ignition temperature: No data found.
Decomposition temperature: No data found.
Upper/lower flammability or explosive limits: No data found.
Vapor pressure: No data found.
Vapor density: No data found.
Evaporation rate: No data found.
Flammability (solid, gas): No data found.
Partition coefficient: n-octanol/water: No data found.
Solubility: Miscible in water.
Viscosity: No data found.
Section 10. Stability and Reactivity
Chemical Stability: Stable under recommended temperatures and pressures. It is an oxidizer.
Incompatibility (Materials to Avoid): Organic materials, Powdered metals, Strong reducing agents.
Conditions to Avoid: Incompatible materials, excessive heat and light.
Hazardous Decomposition Products: Oxygen that supports combustion.
Hazardous Polymerization: Will not occur.
Section 11. Toxicological Information
Toxicity to Animals:
LD50 Oral 50% solution: LD50 > 225 mg/kg bw (rat)
LD50 Oral 35 % solution:LD50 1193 mg/kg bw (rat)
LD50 Oral 70 % solution: LD50 1026 mg/kg bw (rat)
Carcinogenicity: IARC: 3- Group 3: Not classifiable as to its carcinogenicity to humans (Hydrogen peroxide).
Teratogenic Effects: No data found.
Mutagenic Effects: No data found.
Developmental Toxicity: No data found.
Reproductive Effects: No data found.
Section 12. Ecological Information
Ecotoxicity: Very toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment.
Toxicity to fish: LC50 semi-static test Pimephales promelas: 16.4 mg/l / 96 h.
Toxicity to daphnia and other aquatic invertebrates: EC50 semi-static test Daphnia pulex: 2.4 mg/l / 48 h
Results of PBT and vPvB assessment: This substance/mixture contains no components considered to be either persistent, bioaccumulative and toxic (PBT), or very persistent and very bioaccumulative (vPvB) at levels of 0.1% or higher.
Persistence and Degradability: Unlikely to persist due to water solubility.
Mobility: Mobile due to water solubility.
Section 13. Disposal Suggestions
Dispose of in accordance with all applicable local, state and federal regulations at an approved waste disposal facility.
Section 14. Transport and Label Information
Land Transport DOT USA, TDG Canada & ADR/RID Europe:
UN number: 2014 Class: 5.1 (8) Packing group: II
Proper shipping name: HYDROGEN PEROXIDE, AQUEOUS SOLUTION
Sea Transport IMDG/IMO:
UN number: 2014 Class: 5.1 (8) Packing group: II
Proper shipping name: HYDROGEN PEROXIDE, AQUEOUS SOLUTION
Air Transport IATA/ICAO:
UN number: 2014 Class: 5.1 (8) Packing group: II
Proper shipping name: HYDROGEN PEROXIDE, AQUEOUS SOLUTION
Section 15. Regulatory Information
USA:
SARA 311/312 Hazards: See section 2.
California Prop. 65 Components: This product does not contain any chemicals known to State of California to cause cancer, birth defects, or any other reproductive harm.
Section 16. Other Information
European Labeling in Accordance with EC Directives:
H272 May intensify fire; oxidizer
H301 Toxic if swallowed.
H314 Causes severe skin burns and eye damage.
H332 Harmful if inhaled
H335 May cause respiratory irritation.
H412 Harmful to aquatic life with long lasting effects.
DISCLAIMER: The information and recommendations set forth herein are presented in good faith and believed correct as of the date hereof. It is compiled from various sources, and it is not necessarily all inclusive nor fully adequate in every circumstance. In addition, these suggestions should not be confused with nor followed in violation of applicable laws, regulations, rules, or insurance requirements applicable. This SDS MSDS sheet is intended only as a guide to the appropriate precautionary handling of the material by a professionally trained person using this product. Individuals receiving the information must exercise their independent judgment in determining its appropriateness for a particular purpose. This shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. In no case shall our company be liable to loss or damages by the product user.
Please visit Main Page of Hydrogen Peroxide Suppliers.
American Molecules, also known as ammol.org is a distributor, supplier and manufacturers' representative of all types of Pharmaceuticals, Functional Ingredients, Excipients and Specialty Chemicals in Texas USA. Our principals manufacture supply and export USP NF BP, Ph Eur, etc grades of chemicals pure and reagent grade, mineral fortifiers, FCC food grade. Tailor made particle size and customized specifications are offered. The principal's facility is having one or more of the certifications like FDA approval and GLP, cGMP, ISO9001, ISO14001, ISO/IEC 17025, ISO22000, FSSC 22000, ISO45001, FSSAI, Kosher, HALAL, COPP, WHO-GMP certified and Written Confirmation (WC) for export to Europe is available. The manufacturers suppliers and exporters observe WHO Good Manufacturing Practices and Good Laboratory Practices.
Suppliers and Manufacturers' Representative:
9910 Bent Oak Dr
Houston, TX 77040, USA
Call Toll Free: 1-855-55-AMMOL 1-855-552-6665
Email: info@ammol.org